2009-2010 Ski-Doo REV-XP/XR 2 Stroke and REV-XR 1200 4-TEC Service Manual, Page 754Get this manual

2009-2010 Ski-Doo REV-XP/XR 2 Stroke and REV-XR 1200 4-TEC Service Manual, Page 754

Section 02 ENGINE Subsection 05 (COOLING SYSTEM)
Connect the VACUUM PRESSURE PUMP (PIN 529 021 800) to the test cap nipp le
TYPICAL Coolant re servoir 2Coolant 15mm (12 in) above COLD LEVEL line

15When engine has completely cooled down, recheck coolant level in coo lant reservoir and refi ll up to line if needed16Check coolant freezing pointCOOLANT RECOMMENDED FREEZING POINT

Pressu rize system through coolant reservoirTEST PRESSURE 100kPa (15PSI)

17Adjust mixture as necessary18Reinsta ll removed parts 19Run ve hicle few minutes then recheck coolant level
INSPECTION
COOLING SYSTEM LEAK TEST