2009-2010 Ski-Doo REV-XP/XR 2 Stroke and REV-XR 1200 4-TEC Service Manual, Page 700Get this manual

2009-2010 Ski-Doo REV-XP/XR 2 Stroke and REV-XR 1200 4-TEC Service Manual, Page 700

Section 01
MAINTENANCE

Subsection 03 (PRESEASON PREPARATION)

PRESEASON PREPARATION
SERVICE PRODUCTS
Description Part Number Page PULLEY FLANGE CLEANER413 711 809 13- 14 XP-S SYNTHETIC GREASE 293 550 10 14

GENERAL
Proper vehicle preparation is necessary after the summer months or when vehicle has not been used for more than three monthsRefer to preseason preparation column from MAIN TENA NCE CHART jointly with the present procedures in order to cover each and every aspect of the snowmobile preseason preparation Any worn, broken or damaged parts found should be replaced
Air Intake Silencer Filter
Ensu re that air intake silencer filter is properly installed and in good condition Rinse filter with fresh water to clean or replace if damaged
FUEL SYSTEM
Inspect fue system for leaks Refer to FUEL TA NK ND FUEL PUMP subsection
Throttle Body
Unless otherwise specified, engine should be ration ureturn ed off for
Using the PULLEY FLANGE CLEANER (PIN 413711 809 ), clean he throttle plate and throttle body bores NOTE: To ease clean ing, remove throttle body from intake manifold and air intake silencer ithout disconnecting throttle cable and coolant hoses