1990-1998 Arctic Cat Snowmobiles Repair Manual, Page 294Get this manual
CHAPTER NINE
4Install by reversing the preceding removal stepsBefore attaching the electrical connectors to the unit, make sure the connectors are cleanUse electrical contact cleaner to clean the connectorsVOLTAGE REGULATOR The voltage regulator is attached to the vehicle frameRefer to Figure 34 for typical installation1Disconnect voltage regulator wires2Remove the nut and screw from the center of the voltage regulator3Installation is the reverse of the preceding stepsBefore connecting the electrical wire connectors at the unit, make sure the connectors are cleanUse electrical contact cleaner to clean the connectorsTesting Refer to Chapter Two for testing and troubleshooting the charging system, including the voltage regulatorLIGHTING SYSTEM The lighting system consists of the headlight, taillightbrakelight combination, instrument warning illumination lights and pilot lampsIn the event of trouble with any light, the first thing to check is the affected bulb itselfIf the bulb is good, check all wiring and connections with test light or ohmmeterHeadlight Replacement (Single-bulb Type)