1999 Polaris SLH, SLTH, SLX, SLTX, PRO785 Factory Service Manual, Page 61Get this manual
MAINTENANCErrUNE UP HullDeck Storage Compartment Door Adjustment
The storage compartment seal must be in good condition to prevent water from enteringCarefully inspect the condition of the seal and make sure it is securely fastenedCompartment Door AlignmentSLT Models NOTE: On SLT models, do not close compartment door with hinge nuts, latch striker plate, or latch post looseThe door may be extremely difficult to re-open
Open storage compartment door and make sure rubber guide bumpers are in place and in good conditionVisually check alignment of door along both edges The gap should be equal on both sidesIf adjustment is necessary, mark location of hinges with pencil for referenceRemove storage bucket and loosen two main hinge nuts (inside under top deck) just enough to allow adjustment of doorShift door to side of smaller gap until equal on both sides
5Hold door in position and tighten nuts67Carefully close door and check alignmentRe-adjust if necessary until door is aligned along both edgesWhen properly aligned, check to make sure it latches securely and tightly