2006 SD Johnson 4 Stroke 9.9-15HP Outboards Service Manual, Page 42Get this manual
INSTALLATION AND PREDELIVERY RUNNING CHECKS IMPORTANT: DO NOT perform break-in using a flushing deviceDO NOT start-up or run the engine out of waterDO NOT leave running engine unattendedDuring the break-in, check water pump operation oftenLook for steady stream of water from the water pump indicatorIf the stream of water stops, shut off the engine to prevent damageFind and correct the cause before continuingChange the RPM often Avoid holding throttle setting longer than 15 minutesCheck the crankcase oil level oftenAdd oil if neededFirst 10 minutes of operation in gear at idle onlyOperate engine
Fuel System
Perform running checks of the fuel system by following these steps: Squeeze fuel primer bulb until hard or activate electric primerObserve all fuel hoses and connectionsRepair any leaks Start outboardVisually inspect all oil hoses and connections and fuel hoses and connections Repair any leaks or misrouted hoses
Emergency Stop Switch
Check emergency stop functionWith outboard running at IDLE, pull safety lanyard from emergency stop switchOutboard must stop immediately