2004 SR Johnson 4 Stroke 9.9-15HP Outboards Service Manual, Page 8Get this manual
GENERAL INFORMATION GENERAL PRECAUTIONS
!ACAUTION! If parts replacement is necessary, replace the parts with EvinrudeJohnson Genuine Parts or their equivalent When removing parts that are to be reused, keep them arranged in an orderly manner so that they may be reinstalled in the proper order and orientation Be sure to use special tools when instructed Make sure that all parts used in assembly are clean and also lubricated when specified When use of certain type of lubricant, bond, or sealant is specified, be sure to use the specified type When removing the battery, disconnect the negative cable first and then the positive cableWhen reconnecting the battery, connect the positive cable first and then the negative cable When performing service to electrical parts, if the service procedures do not require using battery power, disconnect the negative cable at the battery Tighten cylinder head and case bolts and nuts, beginning with larger diameter and ending with smaller diameterAlways tighten from inside to outside diagonally to the specified tightening torque Whenever you remove oil seals, gaskets, packing, O-rings, locking washers, locking nuts, cotter pins, circlips, and certain other parts as specified, always replace them with newAlso, before installing these new parts, be sure to remove any left over material from the mating surfaces Never reuse circlipWhen installing new circlip, take care not to expand the end gap larger than required to slip the circlip over the shaftAfter installing circlip, always ensure that it is completely seated in its groove and securely fitted Use torque wrench to tighten fasteners to the torque values when specifiedRemove grease or oil from screw bolt threads unless lubricant is specified After assembly, check parts for tightness and operation To protect the environment, do not unlawfully dispose of used motor oil, other fluids, and batteries To protect the Earth's natural resources, properly dispose of used motor parts