1968 Evinrude Starflite 100 HP outboards Service Manual, Page 88Get this manual
bDisconnect stator lead connectorsSee Figure -17Remove three screws and lift stator from power headSee Figure 7-19cPlace new stator in position and attach with three screws dipped in Loctite grade Screw LockTighten screws with 48 to 60 inch-pounds of torqueReconnect stator lead connectors Be sure distributor cap is properly seated in base before tightening screwsdInstall flywheel as described in Section 5Figure 7-19Removing Alternator Stator
CHARGING CIRCUIT CHECKS
Where To Look Cause What To Do UNDERCHARGED BATTERY BATTERY Result
1Defective battery or worn out battery 2Low electrolyte level 3Corroded terminal connections 4Loose terminal connections 5Excessive electrical load
Check state of charge Add water Clean with wire brush and coat with petrolatum Tighten securely Check total current draw in circuit Replace regulatorsee "Checking Voltage Regulator"
6Defective regulator