2007-2010 Kawasaki Ultra 250X/260X/260LX PWC Factory Service Manual, Page 57Get this manual
PERIODIC MAINTENANCE 2-35 Periodic Maintenance Procedures
Check that the hose jOints are securely connected OPush and pull [Aj the hose joint [Bj back and forth more than two times, and make sure it is lockedIf it does not lockedreinstall the hose jOint
A WARNING
Make sure the hose joint is installed correctly on the delivery pipe by sliding the joint, or the fuel could leak
Rubber Strap Inspection
Check the following rubber straps for any deterioration or damagePull on squeeze the straps and look for cracks Battery Straps [Aj Fuel Tank Straps Water Box Muffler Straps If strap is damage in any way, replace it
Fuel Hose Replacement
A WARNING
Gasoline is extremely flammable and can be explosive under certain conditionsTurn the ignition switch OFFDo not smokeMake sure the area is well ventilated and free from any source of flame or sparks; this includes any appliance with pilot light Remove the fuel hose (see Fuel Hose Removal in the Fuel System chapter) Replace the fuel hose with new ones When installing the fuel hoseroute the hose according to CableWireand Hose Routing section in Appendix chapter When installing the fuel hose, avoid sharp bendingkinkingflattening or twistingand route the fuel hose with minimum of bending so that the fuel flow will not be obstructed Check that the hose joints are securely connected (see Hose and Hose Connect Inspection) Start the engine and check the fuel hose for leaksIII III