2008 Polaris Ranger RZR Service Manual, Page 24Get this manual
MAINTENANCE 6Once the proper adjustment is obtained, place the shift cable and upper jam nut into the mountTighten the lower jam nut against the mountStart engine and shift through all gears to ensure the shift cable is properly adjustedIf transmission still ratchets after cable adjustment, the transmission will require service2Be sure fuel line is routed properlyIMPORTANT: Make sure line is not kinked or pinched3Replace fuel line every two yearsFuel PumpFuel Filters
The 800 EFI RZR engine uses non-serviceable, high-volume, high-pressure, fuel pump that includes preliminary filter and an internal fine filter located before the pump regulatorFuel Pump Asm
FUEL SYSTEM AND AIR INTAKE
Fuel System WARNING
Gasoline is extremely flammable and explosive under certain conditionsAlways stop the engine and refuel outdoors or in well ventilated areaDo not smoke or allow open flames or sparks in or near the area where refueling is performed or where gasoline is storedDo not overfill the tankDo not fill the tank neckIf you get gasoline in your eyes or if you swallow gasoline, seek medical attention immediatelyIf you spill gasoline on your skin or clothing, immediately wash it off with soap and water and change clothingNever start the engine or let it run in an enclosed areaEngine exhaust fumes are poisonous and can result loss of consciousness or death in short timeNever drain the fuel when the engine is hotSevere burns may result