2005-2009 Kawasaki Brute Force 650/KVF 650 4x4 Service Manual, Page 42Get this manual
2-24 PERIODIC MAINTENANCE Periodic Maintenance Procedures
Remove the drain plug [A] on the muffler In an open area away from combustible materials, start the engine with the transmission in neutral Raise and lower engine speed while tapping on the muffler with rubber mallet until carbon particles are purged from the muffler
A WARNING
Do not run the engine in closed areaExhaust gases contain carbon monoxide; colorless, odorless, poisonous gasBreathing exhaust gas leads to carbon monoxide poisoning, asphyxiation, and death
Stop the engine Install the drain plug
Converter System
Drive Belt Inspection
Inspection of the drive belt is required at least every 90 days of vehicle use (average 12 mileday) not to exceed 700 km (1 100 mile) or belt indicator light turn on (100 hours of use) counted by the hour meterMore frequent inspection is necessary if the vehicle is subjected to hard usage