2006-2012 Honda TRX90 TRX90EX/X Service Manual, Page 201Get this manual
FRONT WHEEUBRAKE SUSPENSIONSTEERING Install rubber plug into the injury as follows: Apply cement to plug inserting needle and work the needle into the injury to clean and lubricate itDo this three timesDo not let the cement dryInsert and center rubber plug through the eye of the inserting needleApply cement to rubber plugPush the inserting needle with plug into the injury until the plug is slightly above the tireBe careful not 0 push the plug all the way il1lo the lire 10 prevent from fallmg inside
Twist the needle and remove it from the tire; the plug will stay in the tireTrim the plug mm (14 in) above the tire surfaceRepeat the above procedure if the puncture is largeDo not use more than two plugs per injuryAllow the repa ir to dryDrying time will vary ith air temperatureRefer to he tire repair kit manufacturer's recommendationsInflate the tire and test the seal by dabbing small amount of cement around the plug Escaping air will cause bubble in the cementIf there is leakageremove he tire (page 12-1 3) and apply cold patch the inside of the tire