2004-2006 Honda FourTrax Rancher TRX350TE/TM/FE/FM Service Manual, Page 235Get this manual
FRONT WHEELSUSPENSIONSTEERING In sert and center rubber plug through the eye of the inserting needleApply cement to the rubber plugPush the inserting need le with plug into the injury until the plug is slightly above the tireBe careful not 10 Twist the needle and re move it from the tire; the pUSh Ille plug all plug will stay in the tire rile wav mlo ihe tire Trim the lu mm (1 4 in) above the tire surfaceiO prevent If from Repeat the above procedure if the puncture is largefalling rn sldeDo not use more than two plugs per inj uryAllow the repair to dryDrying time wil vary with air emperatureRefer to the tire repair kit manufactu rer's recommen dations, Inflate the tire and test the seal by dabbing small amount of cement around the plugEscaping air wi ll cause bubble in the cementIf here is leakage, remove the tire (page 13-12) and app ly cold patch to the inside of he tire as described If plug has been inserted, trim it even wit th inner tire surfaceTemporari ly place rubber patch that is at least twice the size of the puncture over the injuryMake mark around the patch, sli ghtly larger than the patch itselfRough the area marked ins ide the tire with tire buffer or wire brushClean the rubber dust from the buffed areaApply cement over the area marked and allow it to dry unti tacky Do not touch the cement with dirty greasy handsRemove (he lini ng from the patch and center it over the injuryPress the patch against the injury using special roller