1986-1987 Honda TRX350 FourTrax 4X4, 1987-1989 TRX350D Foreman 4X4 Service Manual, Page 170Get this manual
FRONT WHEELSUSPENSIONSTEERING Install rubber plug into the injury as follows: Apply cement to plug inserting needle and work the needle into the injury to clean and lubricate it Do this three times Do not let the cement dry
Insert and center rubber plug through the eye of the inserting needle Apply cement to the rubber plugPush the inserting needle with plug into the injury unt il the plug is slightly above the tireTwist the needle and remove it from the tire; the plug will stay in the tireNOT Be careful not to push the plug all the way into the ire to prevent it from fa lling inside
Trim the plug mm (' 14 inl above the ire surface Repeat the above procedure if the puncture is large Do not use more than two plugs per injury Allow the repair to dry Drying time will vary with air tempera tureRefer to the tire repair kit manufacturer's recommendations
Inflate the tire and test he seal by dabbing small amount of cement around the plug Escaping air will cause bubble in the cement If there is leakageremove the tire (page 12-8) and apply cold patch to the inside of the tire as describedIf plug has been inserted, trim it even with the inner tire surface Temporarily place rubber patch that is at least twice the size of the puncture over the injuryMake mark around the patchslightly larger than the patch itselfRemove the patch Roughen the area marked inside the tire with tire buffer or wire brush Clean the rubber dust from the buffed area