2005-2007 Bombardier Rally 200 Factory Service Manual, Page 44Get this manual
Section 02 ENGINE Subsection 01 (TROUBLESHOOTING)
ENGINE DOES NOT START NO SPARK AT SPARK PLUG (SEE MAGNETO SYSTEM)1Verify spark plug condition- Defective, improperly set, worn out, fouledIdentify source of problem and correctReplace spark plug2Verify ignition coil resistance with an ohmmeter- Defective partReplace ignition coil3Verify trigger coil resistance with an ohmmeter and connector condition- Defective trigger coilCorroded connector terminalReplace trigger coilClean terminals and apply silicone dielectric grease4Verify condition of ignition coil- Mechanically damaged partVibration problemElectrically damaged partReplace ignition coil5Verify condition of trigger coil- Mechanically damaged partVibration problemElectrically damaged partReplace trigger coil andor tighten mounting screw(s)- Metallic particles caused short circuit between the soldered connectionsClean trigger coil from metallic dust6Check magneto for damage andor electrical failure- Windings of stator have electrical failure (no charging causes an empty battery)Replace magneto