2004 Bombardier Quest/Traxter Series Shop Manual, Page 44Get this manual
Section 02 MAINTENANCE Subsection 02 (MAINTENANCE CHART)
LUBRICATION AND MAINTENANCE CHART
Some items may not apply to your particular modelEVERY 100 HOURS OR 2500 KM (1553 OR YEAR 200 HOURS OR 5000 KM (3107 OR YEARS
I: Inspect, verify, clean, adjust, lubricate, replace if necessary C: Clean L: Lubricate R: Replace
50 HOURS OR 1250 KM (777 m
INITIAL 10 HOURS OR 250 KM (150 m
25 HOURS OR 625 KM (388 m
REFER TO
Enginetransmission oil and filter Enginetransmission oil strainer cleaning Spark arrester Engine mount fasteners Exhaust system Condition of seals Coolant Radiator capcooling system pressure test Radiator conditioncleanliness (air ducts and radiator fins) Rewind starter rope condition (if so equipped) Drive belt Cleaningcondition of drive and driven pulleys One-way bearing inside CVT CVT air inlet duct conditioncleanliness and sealing Air filter Fuel lines and connections Fuel tank strainer Carburetor Spark plug(s) Battery electrolyte level, connection and vent Wiring harness, cables and lines Condition of ignition switch, startstop button and engine stop switch Condition of lighting system (hilo intensity, brake light, etc Headlamp beam aiming Winch connection Drive shaft boot and protector Front propeller shaft joint Drive shaft joint Wheel bearing condition Rear propeller shaft joint lubrication (grease fitting) Front differential and rear axle oil level, seals and vents