2003 Bombardier Rally 200 Service Manual, Page 276Get this manual
Section 11 TECHNICAL DATA Subsection 02 (ENGINE AND VEHICLE)
VEHICLE MODEL Magnetogenerator Ignition system type Ignition timing Spark plug Trigger coil (pickup coil) Battery charging coil (lightning coil) ELECTRICAL Ignition coil Engine RPM limiter Engine RPM limiter (reverse) Battery Headlight Taillight Pilot lamp cluster Fuses Carburetor Idle engine speed Main jet Pilot jet Needle jet Jet needle Choke plunger position Adjustment Type Model RPM Type Voltage Nominal rating Power starter output Primary Secondary Quantity Make and type Gap
Fuel LUBRICATION Lubricant Oil pressure switch Oil temperature (max Oil pressure (min Belt width CVT CVTtemperature (max Centrifugal clutch (driven pulley) Coolant COOLING Water temperature switch Water temperature (max Engine thermostat Radiator cap opening pressure Transmission Rear axle Rear axle ratio
Throttle cable Preliminary pilot screw turn 0.5 mm Float level 0.020 in Type Octane no
RALLYTM 200 200 6000 RPM IDI (Inductive Discharge Ignition) Not adjustable NGK CR8E 0.6 to 0.7 (.024 to .027) 190 300 0.6 01 1.87 to 2.53 20C (68F) 10.4 to 15.6 20C (68F) 10500 6000 Electrolyte battery type 12 volts 14 Ah 0.6 KW 30 827 W, 1157 LEDS 25 Mikuni with manual choke VM-24 1500 100 105 22.5 0-2M 5GNY 72-3 Variable mm (.157 in) 34 15 .591 Regular unleaded gasoline 87 (RonMon)2 SAE 5W30 or 5W40 Bombardier synthetic oil mineral based 30 to 60 kPa (4.35 to 8.70 PSI) 120C (248F) 350 kPa (50.76 PSI)