2002 Bombardier Quest 650XT Service Manual, Page 29Get this manual
Section 02 MAINTENANCE Subsection 02 (MAINTENANCE CHART)
LUBRICATION AND MAINTENANCE CHART
Some items may not apply to your particular modelEVERY 50 HOURS OR 1500 KM (930 INITIAL 10 HOURS OR 300 KM (185 25 HOURS OR 750 KM (470 100 HOURS OR 3000 KM (1865 OR ONCE YEAR 200 HOURS OR 6000 KM (3730 OR YEARS
I: Inspect, verify, clean, adjust, lubricate, replace if necessary C: Clean L: Lubricate R: Replace
Enginetransmission oil and filter Enginetransmission oil strainer cleaning Spark arrester Engine mount fasteners Exhaust system Condition of seals Coolant Radiator capcooling system pressure test Radiator conditioncleanliness (air ducts and radiator fins) Rewind starter rope condition (if so equipped) Drive belt Cleaningcondition of drive and driven pulleys CVT air inlet duct conditioncleanliness and sealing Air filter Fuel lines and connections Fuel tank strainer Carburetor Spark plug Battery electrolyte level, connection and vent Wiring harness, cables and lines Condition of ignition switch, startstop button and engine stop switch Condition of lighting system (hilo intensity, brake light, etc Headlight beam aiming Winch connection Drive shaft boot and protector Front propeller shaft joint Drive shaft joint Wheel bearing condition Rear propeller shaft joint lubrication (grease fitting) Front differential and rear axle oil level, seals and vents Throttlehousingcable Choke Handlebar fastener Steering system mechanism Tie rod ends Front wheel alignment Steering adjustment Wheel nutsstuds Wearpressure of tires