2007 Arctic Cat ATVs 400/500/650/700 Service Manual, Page 5Get this manual
General Specifications (500Manual Transmission)
CARBURETOR
Type Main Jet Slow Jet Pilot Screw Setting (turns) Jet Needle Idle RPM (engine warm) Starter Jet Float Arm Height Throttle Cable Free-Play (at lever) Ignition Timing Spark Plug Type Spark Plug Gap Spark Plug Cap Ignition Coil Resistance (primary) (secondary) Keihin CVK36 138 40 34 NFKG 1250-1350 85 17 mm (0.7 in 3-6 mm (18-14 in Coolant Capacity Differential Capacity Rear Drive Capacity Engine Oil Capacity
MISCELLANY
Gas Tank Capacity (rated) 24.6 (6.5 U.Sgal 2.9 (3.0 U.Sqt) 275 ml (9.3 fl oz) 250 ml (8.5 fl oz) 3.4 (3.5 U.Sqt) 87 Octane Regular Unleaded SAE 5W-30 SAE Approved 80W-90 Hypoid DOT 12V8W27W 12V27W (2)
Gasoline (recommended) Engine Oil (recommended) DifferentialRear Drive Lubricant Brake Fluid TaillightBrakelight Headlight
ELECTRICAL
10 BTDC 1500 RPM NGK CR6E 0.7-0.8 mm (0.028-0.032 in 8000-12,000 ohms Less than ohm (terminal to ground) 5200-7800 ohms (high tensionplug cap removedto ground) 140-215 DC volts (terminal to ground) 160-240 ohms (green to blue) Less than ohm (yellow to white) Less than ohm (black to black) 4.2-6.3 volts (green to blue) 0.40-0.62 volt (yellow to white) 60 AC volts 5000 RPM (black to black #1) (black to black #2) 325W 5000 RPM